Advertisem*nts
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer / Explorer Sport (U152; 2000, 2001, 2002, 2003, 2004, 2005).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
See Also
2002 Ford Explorer Fuse Box DiagramsFuse Box Diagram Ford Explorer (2002-2005)Fuse Box Diagrams Ford Explorer (U152; 2002-2005) - Fusesinfo.com2002 Explorer Fuse Box Diagram: Exploring the Fuse BoxesTo check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
Passenger Compartment Fuse Box
The fuse panel is located below the instrument panel on the driver’s side.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 30 | Memory seat module, Driver power seat (2003-2005), Driver power lumbar (2005) |
| 2 | 20 | Heated seats (2001-2002), Moonroof |
| 3 | 20 | Radio, Amplifier, Power antenna (2001-2002), DVD |
| 4 | 5 | Front wiper module |
| 5 | 15 | Flasher relay (Turn, hazards) |
| 6 | 10 | Right horn (2001-2002), Key-in-chime (2003-2005) |
| 7 | 15 | Heated mirrors |
| 8 | 5 | Heated PCV (2004-2005; 4.0L engine only) |
| 9 | — | Not used (spare) |
| 10 | 10 | Heated backlight relay coil, Heated seat module (2001-2002), Temp blend actuator (2001-2002), A/C clutch contact |
| 11 | 20 | Heated seats (2003-2005) |
| 12 | 5 | Foglamp switch (2001-2002), 4x4 module |
| 13 | 5 | Overdrive cancel switch, Flex fuel sender (2001-2003) |
| 14 | 5 | PATS module |
| 15 | 5 | Rear wiper module, Cluster, TPMS (2001-2003) |
| 16 | 5 | Power mirror, Manual climate control, TPMS |
| 17 | 15 | Delayed acc. coil, Battery saver, Interior lamps (front and rear), Glove compartment lamp |
| 18 | 10 | Left horn (2001-2003), Flexible fuel pump (2004-2005) |
| 19 | 10 | RCM, PAD indicator (2001-2002) |
| 20 | 5 | Memory driver seat switch, Driver seat module, Body Security Module (BSM), PATS LED, Sunload sensor (2001-2003) |
| 21 | 5 | Instrument cluster, Compass, Flasher coil |
| 22 | 10 | ABS, IVD Controller |
| 23 | 15 | 2001-2003:Brake pedal position switch, Driver brake applied relay, Redundant cruise deactivate switch |
| 24 | 15 | Cigar lighter, OBD II, Neutral tow |
| 25 | 5 | Mode-Temperature actuator for auxiliary climate control, Trailer tow battery charge coil, TPMS (2004-2005) |
| 26 | 7.5 | Reverse park aid, Brake shift interlock, Approach lamp relay coil (2001-2002), IVD switch |
| 27 | 7.5 | Automatic dimming mirror, Digital transmission range sensor, Backup lamps |
| 28 | 5 | Radio (Start)/DVD (Start) |
| 29 | 10 | Digital transmission range sensor, PWR feed to fuse #28 (Start feed) |
| 30 | 5 | Daytime Running Lamps (DRL), Remote solenoid, DEATC climate controller, Manual climate control, Manual climate control temp blend actuator |
Top side
These relays are located on the reverse side of the passenger compartment fuse panel.
| № | Circuits Protected |
|---|---|
| 1 | Flasher relay |
| 2 | Rear defrost |
| 3 | Delayed accessory relay |
| 4 | Open |
| 5 | Battery saver |
| 6 | Open |
| 7 | Open |
Advertisem*nts
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.
| № | A | Circuits Protected |
|---|---|---|
| 1 | 60 | PJB |
| 2 | 30 | BSM |
| 3 | 20 | GCC pusher fan (2001-2002; export only) |
| 4 | 30 | Rear defrost |
| 5 | 40 | Anti-lock Brake System (ABS) pump |
| 6 | 60 | Delayed accessory, Power windows (2004-2005), Audio (2004-2005) |
| 7 | 20 | Power point #2 |
| 8 | 30 | 4x4 shift motor (2004-2005) |
| 9 | 20 | Power point #1 |
| 10 | 30 | ABS module (valves) |
| 11 | 40 | PTEC (2001-2003), Powertrain Control Module (PCM) (2004-2005) |
| 12 | 50 | Ignition relay/Starter relay |
| 13 | 40 | Trailer tow battery. Trailer tow turn signals |
| 14 | 10 | Daytime Running Lamps (DRL) (Canada), Foglamps (2001-2002; export only) |
| 15 | 15 | Memory (KAPWR) (2001-2002), Memory (PCM/DEATC/Cluster) (2003-2005), Courtesy lamps (2003-2005) |
| 16 | 15 | Headlamp switch (2001-2003), Foglamp switch (2003), Park lamps (2004-2005), Autolamp parklamps (2004-2005), Front foglamps relay coil (2004-2005) |
| 17 | 20 | 4x4 (v-batt 2) (2001-2003) |
| 5 | Two-speed 4x4 (relay coils) (2004-2005) | |
| 18 | 20 | 4x4 (v-batt 1) (2001-2003), PCM with two-speed 4x4 clutch (2004-2005) |
| 19 | 20 | High beam relay |
| 20 | 30 | Trailer electric brake module |
| 21 | 30 | Front wiper motor |
| 22 | 20 | Autolamp; Low beam |
| 23 | 30 | Ignition switch, PCM diode (2004-2005) |
| 24 | 20 | Rear fog lamps (2001-2002; export only) |
| 25 | 15 | Brake on-off (2004-2005) |
| 26 | 15 | Fuel pump (2001-2003) |
| 20 | Fuel pump (2004-2005) | |
| 27 | 20 | Trailer tow lamps, Trailer tow back-up |
| 28 | 20 | Horn relay |
| 29 | 60 | PJB |
| 30 | 20 | Rear wiper motor |
| 31 | — | Not used |
| 32 | — | Not used |
| 33 | 30 | Auxiliary blower motor |
| 34 | 30 | Power seats, Adjustable pedals |
| 35 | 20 | Rear power point (2001-2002) |
| 36 | 40 | Blower motor |
| 37 | 15 | A/C clutch relay/Transmission |
| 38 | 15 | Coil on plug (2001-2003), HEGO (2004-2005), VMV (2004-2005), CMS (2004-2005), ESM (2004-2005), CVS (2004-2005) |
| 39 | 15 | Injectors/Fuel pump relay |
| 40 | 15 | PTEC power (2001-2003), PCM power (2004-2005) |
| 41 | 15 | HEGO (2001-2003), VMV (2001-2003), CMS (2001-2003), PTEC (2001-2003), Coil on plug (2004-2005; 4.6L engine only), Ignition coil (2004-2005; 4.0L engine only) |
| 42 | 10 | Right low beam |
| 43 | 10 | Left low beam |
| 44 | 15 | Front foglamps |
| 45 | 5 | Brake pressure switch (2001-2002) |
| 2 | Brake pressure switch (ABS) (2003-2005) | |
| 46 | 20 | High beams |
| 62 | 30 | Circuit Breaker:Delayed accessory (2001-2002), Power windows circuit breaker (2003-2005) |
| 47 | Horn relay | |
| 48 | Fuel pump relay | |
| 49 | High beam relay | |
| 50 | Fog lamp relay | |
| 51 | Police IVD relay | |
| DRL relay (Canada) | ||
| 52 | A/C clutch relay | |
| 53 | Trailer tow right turn | |
| 54 | Trailer tow left turn | |
| 55 | Blower motor relay | |
| 56 | Starter relay | |
| 57 | PTEC relay | |
| PCM relay | ||
| 58 | Ignition relay | |
| 59 | Driver brake applied or DRL relay (Canada only) | |
| 60 | PCM diode | |
| 61 | A/C clutch diode | |
Advertisem*nts
Rear Relay Box
The relay box is located on the rear passenger side quarter trim panel.
| № | Circuits Protected |
|---|---|
| 14 | Not used |
| 15 | Trailer tow back- up lamps |
| 16 | Not used |
| 17 | Not used |
| 18 | Not used |
| 19 | Trailer tow park lamps |
| 20 | Trailer tow battery charge |
| 21 | Not used |
| 22 | Approach lamps |
| 23 | Not used |
| 3 | Not used |
| 4 | Not used |
Auxiliary Relay Box
The relay box is located on the front right fender well underneath the speed control module (Canadian vehicles equipped with AdvanceTrac).
| № | Circuits Protected |
|---|---|
| 64 | Police vehicles equipped with AdvanceTrac® |
| Two-speed 4x4 motor clockwise (2004-2005) | |
| 65 | Two-speed 4x4 motor counterclockwise (2004-2005) |
| 66 | Open |
Advertisem*nts
